服务热线:
400-879-1999
联系我们
服务热线
400-879-1999
电话:400-879-1999
地址:山东省莱州市206国道与308省道交叉口东南50米
当前位置:首页 > 中科资讯 > 新闻资讯 > 中科混凝土搅拌机的安全规范的使用
中科混凝土搅拌机的安全规范的使用
来源:http://www.cnzkjf.cn发布日期:2021-02-19   浏览量:
 
混凝土搅拌车就目前来说,主要存在湿料式、干料式和半干料式三种搅拌运输车,自上料混凝土搅拌车若不安全进行操作,将会引起翻车、液压泵、马达、减速机过快磨损甚至出现严重后果,下面小编根据使用混凝土搅拌机应遵守的安全操作规范为大家作出了如下介绍。
At present, there are mainly three types of concrete mixer truck: wet material mixer truck, dry material mixer truck and semi dry material mixer truck. If the self loading concrete mixer truck is not operated safely, it will cause overturning, hydraulic pump, motor, reducer too fast wear and even serious consequences. According to the safety operation specifications that should be observed when using concrete mixer, the following suggestions are made Introduction.
1、拌筒的旋转方向应符合箭头指示方向,如不符实,应更正电机接线。
1. The rotation direction of the mixing drum shall conform to the direction indicated by the arrow. If not, the motor wiring shall be corrected.
2、混凝土搅拌机应实施二级漏电保护,上班前电源接通后,必须仔细检查,经空车试转认为合格,方可使用。试运转时应检验拌筒转速是否合适,一般情况下,空车速度比重车(装料后)稍快2~3转,如相差较多,应调整动轮与传动轮的比例。
2. The concrete mixer shall be provided with secondary leakage protection. After the power is connected before going to work, it must be carefully checked. It can only be used after it is considered qualified by the empty car test run. During the trial run, it is necessary to check whether the rotation speed of the mixing drum is appropriate. Generally, the speed of the empty truck is slightly faster than that of the truck (after loading). If there is a large difference, the ratio of the driving wheel and the driving wheel should be adjusted.
3、搅拌车应设置在平坦的位置,用方木垫起前后轮轴,使轮胎搁高架空,以免在开动时发生走动。
3. The mixer truck should be set in a flat position, and the front and rear axles should be padded with square wood to make the tires empty, so as to avoid walking when starting.
4、检查传动离合器和制动器是否灵活可靠,钢丝绳有无损坏,轨道滑轮是否良好,周围有无障碍及各部位的润滑情况等。
4. Check whether the transmission clutch and brake are flexible and reliable, whether the wire rope is damaged, whether the track pulley is in good condition, whether there are obstacles around and the lubrication of various parts.
5、当混凝土搅拌机完毕或预计停歇1h以上,除将余料出净外,应用石子和清水倒入抖筒内,开机转动,把粘在料筒上的砂浆冲洗干净后全部卸出。料筒内不得有积水,以免料筒和叶片生锈。同时还应清理搅拌筒外积灰,使机械保持清洁完好。
5. When the concrete mixer is finished or is expected to stop for more than 1 hour, in addition to discharging the remaining materials, stones and clean water shall be poured into the shaking drum, and the machine shall be started to rotate, and all the mortar adhered to the drum shall be washed and discharged. There shall be no water in the barrel to prevent the barrel and blade from rusting. At the same time, the ash accumulation outside the mixing drum should be cleaned to keep the machinery clean and intact.
6、开机后,经常注意搅拌机各部件的运转是否正常。停机时,经常检查搅拌机叶片是否打弯,螺丝有否打落或松动。
6. After starting up, always pay attention to whether the operation of each part of the mixer is normal. When stopping the machine, always check whether the mixer blade is bent and whether the screw is broken or loose.
7、下班后及停机不用时,应拉闸断电,并锁好开关箱,以确保安全。
7. After work and when the machine is not in use, the switch should be turned off and the switch box should be locked to ensure safety.
以上就是使用中科聚峰混凝土搅拌车应遵守的安全操作规范,想必大家在以后的使用中会更加小心谨慎了,想了解更多资讯么?请继续关注我们:http://www.cnzkjf.cn
The above is the use of kejufeng concrete mixer should abide by the safety operation specification, I think you will be more cautious in the future use, want to know more information? Please continue to follow us: http://www.cnzkjf.cn

莱州中科聚峰机械有限公司
电话:15098551508 地址:山东省莱州市206国道与308省道交叉口东南50米
聚峰机械专注生产销售自动搅拌车、自动搅拌机,厂家直销,型号齐全,经久耐用,质优价廉;以规范的管理为依托,以专业的技术为支持,安全可靠,让您放心选择!