Self feeding concrete mixer is a machine that mixes cement, sand and water into concrete mixture. It is mainly composed of a mixing bucket, a feeding and discharging mechanism, a water supply system, a prime mover, a transmission mechanism, a frame and a support. Only safe and reasonable equipment operation can improve the performance of the equipment. Therefore, the following editor will introduce you to the safe operation procedures of the equipment.

1.在驾驶之前，您需要仔细检查车辆的状况，以确保可以地驾驶车辆。

1. Before driving, you need to carefully check the condition of the vehicle to ensure that you can drive the vehicle safely.

2.如果装卸车停在室外，则在装料之前，必须将搅拌桶内翻，并倒掉水和碎屑，以确保混凝土的质量。

2. If the loading truck is parked outdoors, the mixing drum must be turned inside and the water and debris must be poured out before loading to ensure the quality of concrete.

3.运输混凝土时，请将其牢固放置，以使倾斜的槽不会松动和摇摆，在驾驶时伤害行人或影响其他车辆的正常运行。当心混凝土溢流和地面污染。

3. When transporting concrete, please place it firmly so that the inclined groove will not loosen and swing, which will hurt pedestrians or affect the normal operation of other vehicles during driving. Beware of concrete overflow and ground pollution.

4.从自进料搅拌车运输混凝土的时间不能超过搅拌站指定的时间。在运输混凝土期间，请勿长时间停止搅拌桶，以防止混凝土分离。驾驶员应始终注意具体情况，如果发现任何异常，应通知主控制室并进行。

4. The time for transporting concrete from the self feeding mixer truck shall not exceed the time specified by the mixing plant. During the transportation of concrete, do not stop the mixing bucket for a long time to prevent concrete separation. The driver should always pay attention to the specific situation. If any abnormality is found, he should notify the main control room and treat it.

5.在汽车上安装混凝土时，现场停机时间不应超过一小时。如果是加班工作，现场负责人必须及时做出回应。

5. When installing concrete on the vehicle, the on-site shutdown time shall not exceed one hour. In case of overtime work, the person in charge of the site must respond in time.

6.从装载搅拌机上不进行泵送时，从混凝土到燃料箱的时间不应超过2小时，并且应在2小时或更长时间后排出。如果雨中温度较低，请不要超过2.5小时。

6. Without pumping from the loading mixer, the time from the concrete to the fuel tank shall not exceed 2 hours and shall be discharged after 2 hours or more. If the temperature is low in the rain, do not exceed 2.5 hours.

7.喷射混凝土之前，必须在搅拌前以10-12rpm的转速旋转搅拌筒1分钟。

7. Before shotcrete, the mixing drum must be rotated at the speed of 10-12 rpm for 1 minute before mixing.

8.现在不再提供充气搅拌器，应冲洗并排净入口，排水料斗和排水槽，以阀体上的污垢和残留的混凝土。保持车辆的卫生。

8. The aerated agitator is no longer provided. The inlet, drain hopper and drain tank should be flushed and drained to remove dirt and residual concrete from the valve body. Keep the vehicle clean.

机械设备在操作和使用过程中需要某些的操作过程。您需要知道如何在驾驶时操作独立的搅拌车。基于以上知识，我希望您正确使用和使用它。

Mechanical equipment needs some safe operation process in the process of operation and use. You need to know how to safely operate an independent mixer while driving. Based on the above knowledge, I hope you can use it correctly.